1. Home
  2. Forums
  3. Technical Troubleshooting

Crown RC5500:
Line contactor won't come in when pedals are pressed.

Lift went down last weekend. No travel but all other functions are working. No codes are being shown either. All there is to go on is the line contactor won't come in when pedals are pressed but the pump contactor will. Have not found any wiring or fuse issues as of yet but resistance on the contactor coil is at the upper limit according to Crown (49 ohms)
  • Posted 22 Aug 2023 06:14
  • Discussion started by Michael_Webb
  • North Carolina, United States
Post a ReplyReport this post

Post your Reply

Forkliftaction.com accepts no responsibility for forum content and requires forum participants to adhere to the rules. Click here for more information.

Having trouble using the Discussion Forums? Contact us for help.

Showcased in the Virtual Expo

From the forum discussions …
"Transmission yoke u joint... I have never seen one break. Situations that could cause this are many... Going full throttle from a standstill with a load. Pushing loads or carrying loads too heavy for the lift."
Fishmech, United States
Read & Post in our Forums
Movers & Shakers
Bennit Schmieder Bennit Schmieder
Bennit Schmieder
President, EP Equipment Europe
Mathias Höglund
Senior vice president human resources, Kalmar
Berry Mansfield
President, Mitsubishi Logisnext Americas
Gaurav Sood
Chief executive officer, Messe Stuttgart India
Last Week's Most Read
edition #1226 - 17 April 2025
Forklift Diaries
Movers & Shakers
Bennit Schmieder Bennit Schmieder
Bennit Schmieder
President, EP Equipment Europe
Mathias Höglund
Senior vice president human resources, Kalmar
Berry Mansfield
President, Mitsubishi Logisnext Americas
Gaurav Sood
Chief executive officer, Messe Stuttgart India
Toyota moves to settle US emissions case San Francisco, CA, United States
Forklift Diaries
From the forum discussions …
"...If you can find the signal wire from LHC. To the coils then you can check for volts...You may be getting the correct signal but have a valve issue"
John_Bradley, United States
Read & Post in our Forums
Fact of the week
In 1903, the first Tour de France was held in Paris. The cycling race had been postponed and prize money boosted after it failed to draw enough competitors. Invented to lift the circulation of newspaper L'Auto, it comprised of six long stages totalling 2,428 kilometres.